Section I
3.1
Secton II
Section III
3.2
3.3
3.4
3.5
3.6
3.7
3.8
3.9
3.10
3.11
TM 9-6230-210-13&P
CHAPTER 3
OPERATOR MAINTENANCE INSTRUCTIONS
PAGE
Lubrication Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
Troubleshooting Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
Operator’s Maintenace Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
Floodlight Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-11
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13
Red Warning Light Lenses and Lamps . . . . . . . . . . . . . . . . . . . . . . . . . 3-15
Fuel Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
Fuel Tank Cap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-18
FuelTank Strainer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-19
Ground Rod . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-21
Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-23
SECTION I. LUBRICATION INSTRUCTIONS
3.1 GENERAL
Lubrication instructions are contained in LO 5-6230-210-12.
SECTION II. TROUBLESHOOTING PROCEDURES
3.2 INTRODUCTION.
a. This table lists common malfunctions that you may find your equipment. Perform the inspections and
corrective actions in the order they appear in the table.
b. This table cannot list all the malfunctions that may occur, all the inspections needed to find the fault, or all of the
corrective actions needed to correct the fault. If the equipment malfunction is not listed or actions not listed to correct
the fault, notify your supervisor.
c. Refer to TM 9-2805-258-14 to troubleshoot your generator set.
d. Refer to TM 9-6115-271-14 to troubleshoot your generator set.
e. Refer to TM 9-2330-251-14 to troubleshoot your trailer.
3-1
