TM-9-6230-210-13P Distribution Illumination Systems Electrical (DISE) and Power Distribution Illumination Systems Electrical (PDISE) Manual

CHAPTER 1 INTRODUCTION - TM-9-6230-210-13P_8
1.8    CORROSION PREVENTION AND CONTROL (CPC)
SECTION II. EQUIPMENT DESCRIPTION AND DATA
Figure 1-2. Location and Description of Major Components
LEGEND - TM-9-6230-210-13P_12
1.11 EQUIPMENT DATA.
c. Three circuit breakers (CB)
Figure 1-3. Schematic Wiring Diagram.
CHAPTER 2 OPERATING INSTRUCTIONS
Figure 2-1. Operator Controls and Indicators.
LEGEND - TM-9-6230-210-13P_18
2.4 PMCS    PROCEDURES.
2.6 LEAKAGE DEFINITIONS FOR OPERATOR PMCS.
Table 2-1. Operator Preventive Maintenance Checks and Services - continued
SECTION III. OPERATION UNDER USUAL CONDITIONS
a. Site    Selection.
c. Installing   Rear   Outrigger.
d. Installing   Front   Outrigger.
f. Leveling Unit.
g. Installing   Light   Bar
h. Installing    Floodlights
i.   Installing Power Cords.
Insure that extension lockbar is set
(4) Set tilt lockbar
k. Grounding the Floodlight Set.
LEGEND - TM-9-6230-210-13P_33
2.8 OPERATING   PROCEDURES.
(2) Remove tower cradle cleat
LEGEND - TM-9-6230-210-13P_36
Check overhead clearance
b. Shutdown Procedures
(2) Place floodlight circuit breakers
2.9 DECALS AND INSTRUCTION PLATES.
b. Operating Instructions
c. Warning Plate.
e.    Schematic Wiring Diagram.
2.11 PREPARATION FOR MOVEMENT.
(3) Lowering tower
(c) Release tiilt
(9) Insert tower cradle cleat
(3) Loosen vertical aiming bolt
Allow floodlights to cool before removing
(10) Insert end of Iatch
c. Outrigger Removal.
(4) Front outriggers.
(5) Rear outriggers.
d. Ground Rod Removal.
SECTION IV. WEATHER UNDER UNUSUAL  CONDITIONS
c. Operation In Dusty Or Sandy Areas.
CHAPTER 3 OPERATOR MAINTENANCE INSTRUCTIONS
Table 3-1. Operator Troubleshooting Table
MALFUNCTION 2. All Floodlights Will Not Light.
MALFUNCTION 3. One Floodlight Will Not Light.
MALFUNCTION 4. Red Warning Light Will Not Light.
MALFUNCTION 4. Red Warning Light Will Not Light. -cont
MALFUNCTION 5. Tower Cannot Be Raised to Vertical Position.
MALFUNCTION 5. Tower Cannot Be Raised to Vertical Position - continued.
MALFUNCTION 6. Tower Cannot Be Extended.
MALFUNCTION 6. Tower Cannot Be Extended - continued.
SECTION III. OPERATORS MAINTENANCE PROCEDURES
d. Promotion floodlights .
3.5   BATTERY
Electrolyte
3.6   RED   WARNING   LIGHT   LENSES   AND   LAMPS.
3.7   FUEL   TANK
Ensure that cap is on the fuel tank
3.8   FUEL   TANK   CAP.
3.9   FUEL   TANK   STRAINER.
FUEL   TANK   STRAINER. -cont
3.10   GROUND   ROD.
GROUND   ROD. -cont
3.11   LEVEL
CHAPTER 4 UNIT MAINTENANCE INSTRUCTIONS
SECTION II. SERVICE UPON RECEIPT
(6) Unpacking the Floodlight Set.
(b) (c) (d) 1 Remove two nuts (1) from holddown plate (2). 2 Remove hoedown plate (2). 3 Unscrew and remove bolt (3) toward the outside of the trailer. 4 Remove the battery (4) from the trailer bed. Unpacking battery electrolyte.
b. Checking Unpacked Equipment.
Table 4-1. Generator Set Mounting Hardware
(2)   Battery
Electrolyte
(4) Tower assembly.
(5) Light bar and red warning light.
(6) Ground rod.
(7) Hammer.
(9) Fuel line.
(10) Filling fuel tank.
SECTION III. UNIT PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
4.8 PMCS   PROCEDURES.
4.10 LEAKAGE DEFINITIONS FOR UNIT PMCS.
SECTION IV. UNIT TROUBLESHOOTING PROCEDURES
SYMPTOM INDEX
Table 4-3. Unit Troubleshooting Table
Red Warning Light Does Not Light- continued
MALFUNCTION 2. Flloodlights Will Not Light.
MALFUNCTION 3. Tower Will Not Elevate.
MALFUNCTlON 4. Tower Will Not Elevate
SECTION V. UNIT MAINTENANCE PROCEDURES
MAINTENANCE OF THE FLOODLIGHT SET
4.13   FLOODLIGHT   ASSEMBLY. -cont
FLOODLIGHT   ASSEMBLY. -cont
4.14 TOWER.
TOWER. -cont - TM-9-6230-210-13P_109
TOWER. -cont - TM-9-6230-210-13P_110
TOWER. -cont - TM-9-6230-210-13P_111
TOWER. -cont - TM-9-6230-210-13P_112
TOWER. -cont - TM-9-6230-210-13P_113
4.15   TOWER   TILT   LOCKBAR.
4.16 EXTENSION LOCKBAR.
4.17   RECEPTACLES,   JUNCTION   BOX
RECEPTACLES,   JUNCTION   BOX -cont
4.18   WINCH
WINCH. -cont - TM-9-6230-210-13P_119
WINCH. -cont - TM-9-6230-210-13P_120
WINCH. -cont - TM-9-6230-210-13P_121
WINCH. -cont - TM-9-6230-210-13P_122
4.19   WINCH   CABLE   AND   PULLEYS.
WINCH   CABLE   AND   PULLEYS. -cont - TM-9-6230-210-13P_124
WINCH   CABLE   AND   PULLEYS. -cont - TM-9-6230-210-13P_125
4.20   POWER   CABLE.
POWER   CABLE. -cont - TM-9-6230-210-13P_127
POWER   CABLE. -cont - TM-9-6230-210-13P_128
POWER   CABLE. -cont - TM-9-6230-210-13P_129
POWER CABLE. -cont
4.21 TOGGLE SWITCH AND CIRCUIT BREAKERS.
TOGGLE SWITCH AND CIRCUIT BREAKERS. -cont - TM-9-6230-210-13P_132
TOGGLE SWITCH AND CIRCUIT BREAKERS. -cont - TM-9-6230-210-13P_133
TOGGLE SWITCH AND CIRCUIT BREAKERS. -cont - TM-9-6230-210-13P_134
TOGGLE SWITCH AND CIRCUIT BREAKERS. -cont - TM-9-6230-210-13P_135
4.22   RECEPTACLES.
RECEPTACLES. -cont
4.23 BATTERY, BATTERY TERMINALS, AND WIRES.
BATTERY, BATTERY TERMINALS, AND WIRES. -cont
BATTERY, BATTERY TERMINALS, AND WIRES. -cont - TM-9-6230-210-13P_140
BATTERY, BATTERY TERMINALS, AND WIRES. -cont - TM-9-6230-210-13P_141
4.24   RED   WARNING   LIGHT
RED   WARNING   LIGHT -cont
4.25   FUEL   TANK.
FUEL   TANK. -cont - TM-9-6230-210-13P_145
FUEL   TANK. -cont - TM-9-6230-210-13P_146
4.26   FUEL   TANK   GAUGE.
FUEL TANK GAUGE. -cont
4.27   FUEL   LINE.
FUEL LINE. -cont
4.28 LEVELING JACKS.
LEVELING JACKS. -cont
4.29   CASTER   WHEEL.
CASTER   WHEEL. -cont - TM-9-6230-210-13P_154
CASTER   WHEEL. -cont - TM-9-6230-210-13P_155
4.30   GENERATOR   MOUNTING   HARDWARE.
GENERATOR   MOUNTING   HARDWARE. -cont
4.31   OIL   DRAIN   HOSE
4.32 BATTERY CHARGER.
BATTERY CHARGER. -cont
BATTERY CHARGER. -cont
SECTION VI. PREPARATION FOR STORAGE AND SHIPMENT
CHAPTER 5 DIRECT SUPPORT MAINTENANCE
SECTION Il. DIRECT SUPPORT MAINTENANCE PROCEDURES
5.5   CONTROL   PANEL
CONTROL   PANEL -cont
CONTROL PANEL -cont - TM-9-6230-210-13P_167
CONTROL PANEL -cont - TM-9-6230-210-13P_168
CONTROL PANEL -cont - TM-9-6230-210-13P_169
CONTROL PANEL -cont
5.6 DATA PLATES.
DATA PLATES. -cont - TM-9-6230-210-13P_172
DATA PLATES. -cont - TM-9-6230-210-13P_173
5.7   SPLASH   PANEL
SPLASH   PANEL -cont
SPLASH PANEL -cont - TM-9-6230-210-13P_176
SPLASH PANEL -cont - TM-9-6230-210-13P_177
5.8   BALLAST   BOX.
BALLAST   BOX. -cont
BALLAST BOX. -cont
APPENDIX A REFERENCES - TM-9-6230-210-13P_181
APPENDIX B MAINTENANCE ALLOCATION CHART
B.3 EXPLANATION OF COLUMNS IN THE MAC
B.5 EXPLANATION OF COLUMNS IN REMARKS
SECTION II. MAINTENANCE ALLOCATION CHART
MAINTENANCE ALLOCATION CHART
SECTION III. TOOLS AND TEST EQUIPMENT REQUIREMENTS - TM-9-6230-210-13P_187
APPENDIX C UNIT AND DIRECT SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS
(1) Source Code.
(2) Maintenance Code
e. DESCRIPTION AND USABLE ON CODE (UOC)
C.4 EXPLANATION OF INDEX FORMAT AND COLUMNS
C.5 SPECIAL    INFORMATION.
Figure C-1. Fixture Assembly (Sheet 1 of 3).
Figure C-1. Fixture Assembly (Sheet 2 of 3).
Figure C-1. Fixture Assembly (Sheet 3 of 3).
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_197
Figure C-2. Tower Assembly (Sheet 1 of 2).
Figure C-2. Tower Assembly (Sheet 2 of 2).
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_200
Figure C-3. Bar Assembly.
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_202
Figure C-4. Tower Cradle.
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_204
Figure C-5. Junction Box
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_206
Figure C-6. Winch Assembly TOwer.
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_208
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_209
Figure C-7. Power Cable
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_211
Figure C-8. Control Panel Assembly.
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_213
Figure C-9. Splash Panel
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_215
Figure C-10. Ballast Assembly
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_217
Figure C-11. Battery.
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_219
Figure C-12. Red Warning Light.
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_221
Figure C-13. Fuel Tank Assembly.
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_223
Figure C-14. Leveling Jacks.
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_225
Figure C-15. Ground Rod Assembly.
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_227
Figure C-16. Level Circular.
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_229
Figure C-17. Generator Mounting and Drain Hose.
DESCRIPTION AND USABLE ON CODES - TM-9-6230-210-13P_231
SECTION III. SPECIAL TOOLS LIST
NATIONAL STOCK NUMBER INDEX
STOCK NUMBER - TM-9-6230-210-13P_234
STOCK NUMBER - TM-9-6230-210-13P_235
PART NUMBER INDEX - TM-9-6230-210-13P_236
PART NUMBER - TM-9-6230-210-13P_237
PART NUMBER - TM-9-6230-210-13P_238
PART NUMBER - TM-9-6230-210-13P_239
PART NUMBER - TM-9-6230-210-13P_240
PART NUMBER - TM-9-6230-210-13P_241
FIGURE AND ITEM NUMBER INDEX - TM-9-6230-210-13P_242
FIGURE AND ITEM NUMBER INDEX - TM-9-6230-210-13P_243
FIGURE AND ITEM NUMBER INDEX - TM-9-6230-210-13P_244
FIGURE AND ITEM NUMBER INDEX - TM-9-6230-210-13P_245
FIGURE AND ITEM NUMBER INDEX - TM-9-6230-210-13P_246
FIGURE AND ITEM NUMBER INDEX - TM-9-6230-210-13P_247
APPENDIX D ADDITIONAL AUTHORIZATION LIST (AAL)
APPENDIX E EXPENDABLE/DURABLE SUPPLIES LIST
DESCRIPTION - TM-9-6230-210-13P_250
APPENDIX F COMPONENTS OF END ITEM (COEI) AND BASIC ISSUE ITEMS (BII) LISTS
SECTION II. COMPONENTS OF END ITEM LIST
Description - TM-9-6230-210-13P_253
SECTION Ill. BASIC ISSUE ITEMS

Western Governors University

Privacy Statement
Press Release
Contact

Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business