TM 5-4930-244-14
Chapter 3
OPERATOR MAINTENANCE INSTRUCTIONS
Paragraph
Page
Section I.
Lubrication Instructions ......................................................................................................3-1
Section II.
Operator Troubleshooting Procedures ...............................................................................3-1
3-1.
Introduction ..........................................................................................................................3-1
3-2.
Malfunction Index ..................................................................................................................3-2
3-3.
Troubleshooting Table ...........................................................................................................3-2
Section III.
Operator Maintenance Procedures .....................................................................................3-8
3-4.
General ................................................................................................................................3-8
3-5.
Air Moisture Separator ...........................................................................................................3-8
3-6.
Alcohol Injector ...................................................................................................................3-10
3-7.
Battery Box Assembly .........................................................................................................3-12
3-8.
Air Compressor Assembly Air Filter ......................................................................................3-13
3-9.
Engine Air Cleaner . ...........................................................................................................3-14
3-10.
Wheel and Tire Assembly ....................................................................................................3-15
Section I. LUBRICATION INSTRUCTIONS
See companion publication LO 5-4930-244-12, Lubrication Order.
Section II. OPERATOR TROUBLESHOOTING PROCEDURES
3-1. INTRODUCTION
This section lists common malfunctions that you may find with your equipment Perform the tests, inspections, and
corrective actions in the order they appear in the table.
This manual cannot list all the malfunctions that may occur, all the tests and inspections needed to find the fault, or all the
corrective actions needed to correct the fault. If the equipment malfunction is not listed or actions listed do not correct the
fault, notify your supervisor.
Table 3-1 lists the common malfunctions which you may find during the operation or maintenance of the lubrication and
servicing unit, or its components. You should perform the tests/inspections and corrective actions in the order listed.
3-1
